Replacing Steel Casement Windows
|
I have been getting quite a few emails from homeowners wanting to know how to replace their old steel casement windows. Those are the type with the handle that you crank and the window opens outward. My instructional video didn't cover these windows, so I am going to dedicate two articles to this subject. This first article will cover the removal procedure and measuring for your vinyl windows. Next week I will go over the installation procedure.
The first thing you need to do is order your vinyl replacement windows. You can't remove the old windows until you have the new windows. So, let's start with a single casement window, no fixed panels. Crank the window open from inside and you will see a metal lip approximately 1/2" wide extending from your drywall on all four sides. This part of the frame stays in place, so the new window is going to fit inside those lips. So, to get your width dimension, measure left to right from lip to lip, then subtract 1/4" to get in. Do the same for the height. Let's say you measure 35 3/8" width and 38 3/8" on the height lip to lip. You would order your new window 35 1/8" X 38 1/8". If you live out west, where retrofit frames are available, you want to order the retrofit style frame. In parts of the country where only replacement style frames are available, you will have to add trim to the outside after you have installed the window.
After your windows arrive, it's time to remove the old window. Single casements with no fixed panels are the easiest of the casements to remove. When you crank the window open, you will notice two pivot assemblies. There is one on top and one on bottom. Cut off the metal piece where the pivot pin is attached. Just like that, the entire window frame and glass are removed. Now, remove the crank assembly by removing the screws holding it in place inside the house. The last step is to remove the protruding metal studs that you cut at the pivot to remove the window. The easiest way to do it is to clamp a pair of channel lock pliers or vice grips as close to the frame as possible, then raise and lower the vice grips to break the metal off. That's it.
If you have a combination of casement and fixed panels, you remove the casements as I described. Then, you have to remove the fixed glass. I used to put duct tape all over the outside of the glass. Then, I used one of those 2 dollar glass cutters that you can buy at the hardware store. Put a drop of household oil on the cutter tip before each cut. From inside, score the glass accross the very top of the glass, the very bottom, and along each side. Then, using the tip of a screwdriver, tap the score all the way around the glass. Put a tarp or old sheet down outside the window, take the handle end of a hammer, and knock out the glass at the score. You will have a vertical metal bar in the center where the casement window locked. Using a reciprocating saw or a hacksaw, cut the bar where it meets the frame coming from the drywall. There will be bits of glass protruding beyond the metal lips. You need to knock those out, so they aren't in the way when installing the new window. You can leave the glazing putty in place, since it will be hidden after you have installed the new window. PLEASE WEAR GLOVES AND SAFETY GLASSES DURING THIS ENTIRE REMOVAL PROCEDURE!!
Next week I am going to explain the two types of installation procedures, whether you install retrofit or replacement style frames.
John Rocco has been installingreplacement windows since 1978.
To learn more, visit How To Install Windows
|
|
|
Advice On Waterproofing Your Deck
Even if you undertook the task of building your own deck, you understand the large investment (both monetary and in time) that went into the project. Decks add beauty and value to a home, and are often the family's favorite place on lovely afternoons. In order to protect that investment, deck waterproofing is nearly as important as making sure your basement is dry and safe from water damage.After the completion of your deck, either you or the contracted builder should seal the wood with a water-resistant coating. Water-resistant sealants are painted on the wood, covering the entire deck. This coating helps to protect the wood from absorbing excess water. Not only does this seal the deck but also provides wonderful preservation of the deck's beauty.If...(related: Home Improvement)
How To Install A New Toilet In 5 Easy Steps
If your toilet is old and in need of repairs, it is cheaper to replace it by installing a new one. This is quite easy to do and can be completed in an afternoon. However, if you plan to install a toilet in a new location, you will have to extend supply pipes and drainpipes to the desired spot, a job you may want to leave to a plumbing contractor.Most toilets are sold with the necessary gaskets, washers, and hardware for fitting the tank to the bowl. However you might need to buy a few parts. Here is a list of what you need to complete this task:Parts: T...(related: Home Improvement)
Buying House Plans Online
The Benefits of Self BuildingInvesting in property had always been very popular - and for many very productive and lucrative. However, as the prices on property begin to soar, it is difficult for many to even get their foot on to the property ladder. The alternative is renting, which usually means paying extortionate sums of cash each month to...(related: Home Improvement)
Buying Home Appliances The Smart Way
When you add up all the money that you can spend on home appliances and fixtures it becomes obvious that you need to spend wisely and carefully to keep costs under control. These items tend to be some of the larger ticket purchases around the home and lots of money can be wasted if buying isn't done properly.One of the most important suggestions for buying appliances and fixtures the smart way is to decide before you begin shopping exactly how much money you wish to spend, or what will fit in your budget. Surprisingly, this is often not done until the customer is already in the store. Unfortunately, the heart often takes over when looking over the latest high-t...(related: Home Improvement)
Roof Cleaning - Making Your Old Roof Look Like New!
Many Florida residents that have come from the North are surprised by the idea of roof cleaning - and even more surprised by the fact that many communities here in Florida require it. Reasons for cleaning include aesthetics, prop...(related: Home Improvement)
The Science Of Architecture
You're told to take vitamins, drink plenty of water, get a good night's sleep and exercise, but has anyone ever told you that the design of your home and office can impact your health? You wouldn't be alone in raising an eyebrow and questioning how this could be so, but thousands of years ago, the ancient seers of India spent entire lifetimes observing how man-made structures impact humans beings. Their findings were compiled into a body of knowledge called Vastu Shastra.In Sanskr...(related: Home Improvement)
Wallpaper Doesnt Just Cover...it Defines The Room
Wallpaper is often overlooked as a key part of an attractive home. The right wallpaper will add character to any room in the house, and will also allow a homeowner to cheaply and quickly change the look of their house.From a brightly decorated nursery to a soft bedroom background, wallpaper will create the right tone for any room in your house.It also gives a homeowner a great chance to express their home decorating talents. Unlike paint, so many different patterns and colors are available a homeowner is able to choose exactly the right one.There are so many wallpapers available, you are almost sure to find the one that is just right.Some tips on maintaining your wallpaper.
Top Tips When Planning A Conservatory Or Sunroom
General advice.Negotiate fairly with suppliers. Don't expect to get all mod cons if you're only prepared to pay for the cheapest design.Try to meet the builders who will be doing the work ? it's crucial that you can get on with them.Check whether you'll need planning permission ? don't rely on the conservatory supplier to take care of that for you.Be friendly and cooperative towards the constructors ? you'll have more chance of getting the job done well.If po...(related: Home Improvement)
site-map - Copyright © 2007 | Contact Webmaster | All Rights Reserved | Free Articles and Information | Home Improvement