Installing Retrofit And Replacement Vinyl Windows
|
In previous articles i explained to you how to determine whether your windows are candidates for vinyl replacement style frames or retrofit style frames. This week I'm going to explain the installation techniques for both frame styles. Let's start with the retrofit frame.
Retrofit window installation is really the easiest of all. The retrofit window already comes with an exterior trim attached. That's the flush fin that goes against the outside surface, usually stucco. Prepare the window by drilling 3/8" holes in the areas of the frame where you want to screw it in place. Normally, there will be 3 holes on each side and 3 more across the top. Don't predrill any holes in the bottom track. After removing the old panels, you want to run a heavy bead of caulk on the face of the old aluminum frame that you left in place. Then you and a helper set the bottom of the vinyl window onto the old aluminum bottom track and raise it into position. The flush fin or retrofit lip will act as a "stop" to hold the window in place. Have your helper hold the window while you go inside.
Once inside, you want to center the window in the opening. Slide the vent panel open and closed to make sure the window is plumb and level. To adjust for out of square conditions, shim the bottom right or left corner by placing a shimming material between the sill and bottom of the window frame. Once square, drive a 3" deck screw through the 3/8" holes and into the wood studs.Just seat the screw, don't overtighten. After you get the screws into the sides and top, remove the sliding panel. The bottom track should lift out. Look for drainage holes in the track and insert a thin screwdriver and lift up. Drive one screw in the bottom center, caulk around the screw head, then put the track back in place and re-install the sliding panel. Now, you want to go back outside and caulk the gap where the retrofit fin meets the exterior surface of the house. You want to have a double barrier of protection against water infiltration. Remember, you already applied a generous bead of caulk before inserting the new frame into the opening. The rest of the job is done on the inside.
First, you want to plug the 3/8" screw holes to hide the heads of the screws. We sell the hole plugs on the website. Just click on the "shop" tab to see a picture. The plugs will pop into place in the hole. The next step is to fill the gap around the new frame with R-13 Insulation. Do not use the foam insulation that comes in a can. Many manufacturers will not honor the warranty if the foam is used. Even the non expanding foams can cause the frame to distort, causing problems. Pack the insulation in tight. You might want to wear a dust mask during this procedure. Many people, myself included, are very sensitive to insulation. After the insulation is in place, you want to install trim around the inside to finish the job. You can use wood trim from the hardware store, or some other product. But in my experience, the best product is a vinyl flat trim that matches the window frame. The flat trim can also be purchased on the website under the "shop" tab, or you could try to find it from a local window contractor. Ours comes in 3 different widths, although the 1 3/4" wide piece is by far the most common. The trim has a double sided adhesive tape on the back. You cut the top and bottom first, stick them on the vinyl frame, making sure the trim goes to the drywall. This covers all the insulation and the old metal frame. Do the side pieces next. The final step is to caulk where the trim meets the walls.
Much of the installation process for a replacement frame is the same as the retrofit frame. But, there are a few differences. When you put the new window into the opening using a replacement frame, you don't have the flush fin holding the frame in place. You and your helper have to hold the frame in place while you put a screw in the top center to support the frame. Then, you can do your adjusting for a square condition. All of the procedures on the inside will be exactly the same, from hole plugs, to insulation, to trim and caulk. The outside is different. You have to apply the trim that was part of the retrofit frame. Again, I prefer the flat trim. Once again, you apply a bead of caulk to the old frame,then measure and cut the top and bottom trim pieces. Apply the adhesive part of the trim to the vinyl frame, and let the other part contact the bead of caulk. Trim all four sides, then caulk again where the trim meets the exterior material.
As you can see, it really doesn't matter if the exterior of your home is brick, stone, siding, or stucco. You can install vinyl windows without having to damage the surrounding structure. We have step by step instructional videos for sale on the website at how-to-install-windows.com. Next week we are going to start discussing sliding glass door replacement.
John Rocco has been installing replacement windows since 1978. To learn more, visit How To Install Windows
|
|
|
Repairing Putty Window Glass
Have you ever thought about fixing a broken window in your house, but didn't think you could do it because nobody ever taught you how to cut glass? Well, you really don't have to know how to cut glass in order to repair your window. If you knew how to remove the frame, you could order a replacement piece of glass from your local glass shop already cut to the proper size. Then, it's just a matter of insta...(related: Home Improvement)
The Smart Way To Look At Home Improvements
What home improvements really pay off when the time comes to sell your house?That's an important question for any homeowner contemplating moving or remodeling. And the only possible answer is a somewhat complicated one.That answer starts with the fact that really major improvements ? room additions, total replacements of kitchens and baths, etc., -- rarely pay off fully in the near term. It ends with the fact that small and relatively inexpensive changes can pay off in a big way in making your home attractive to buyers if your decision is to move now.It's a simple fact, consistently confirmed across America over a very long period of time, that ...(related: Home Improvement)
Rustic Stone House Signs
You may own a remarkably constructed, attractive house that is perfect from every angle. The outside of the house is de...(related: Home Improvement)
The Top 10 Mistakes To Avoid When Shopping For A Mattress
Buying a new mattress is a daunting task that few relish. The range of prices, features, and stores can make your head spin. It doesn't have to be this difficult. Bearing a few things in mind while you try and find that perfect place to sleep can ease that big purchase tension.1. Don't limit your mattr...(related: Home Improvement)
Basic Methods Of Foundation Waterproofing
It is absolutely necessary to waterproof the foundation of your home. Foundation waterproofing is a critical step in maintaining your home's value and an important measure for preventing very serious damage. Usually done by professionals, foundation waterproofing is generally not recommended as a do-it-yourself project. Your home is likely your biggest investment, and foundation waterproofing is imperative in order to protect that investm...(related: Home Improvement)
Soy Candles? What Will They Think Of Next?
Quick: What comes to mind when you think of soy candles? Before my formal introduction to soy candles, I thought organic (read ...(related: Home Improvement)
With A Stylish Bathroom Vanity You Can Take Pride In Your Bathroom?s Appearance!
An easy way to instantly improve your bathroom's image is to buy a stylish new bathroom vanity set. Bathroom vanity sets come in a huge range styles and finishes. They typically include a sink cabinet, a mirror and a stool or a chair. A vanity unit can become a stunning focal point of the room and also has a practical function. Combining practicality with elegance and style can be a surefire winner in any bathroom!Your choice of vanity set can reflect your personality and individual style, as well as being a perfect fit with your bathroom's character and design. There are so many different types of vanities out there that it...(related: Home Improvement)
Get The Lead Out: Candle Wicks In The Us
According to the National Candle Association (NCA), most US-manufactured candle wicking is made of cotton or cotton-paper combinations. Nearly 90% of the candles made in the United States (i.e. members of the association) use wicks that contain no lead. Generally, the metal you find in a US-made candle wick is either zinc or tin, which are known to be safe alternatives to lead. With increasing ...(related: Home Improvement)
How To Be Your Air Conditioner?s Best Friend
There are a few things you can do to take care of your air conditioner and make its life a little longer and a little easier.How does your air conditioner work? Simply stated, an air conditioning unit removes heat from the air and blows it outside with an outdoor fan. An indoor fan pulls room air across an evaporator coil filled with refrigerant and transfers cool air into your home. Obviously, the movement of air by fans is a big part of the system. That's why it is so important to replace the filter at least once a month.As dust is picked up, it is trapped on the filter, and you would be surprised how quickly the dust accumulates. Trying to pull air through a clogged filter just makes the fan work harder, raising your utility bill.The same is true for the fan in the outdoor uni...(related: Home Improvement)
Aluminium Window Frames
When double glazing first became a popular window choice in the 1960s, most frames were made of aluminum. Aluminum remained the most popular choice for framing double glazing windows through the mid-1980s, when it held over 60% of the market. Since the introduction of PVC window framing, the market share of aluminum framed windows has dropped steadily. As of 2003, less than 17% of windows sold were aluminum framed. There are many reasons for the drop in popularity - and still some good reasons for choosing aluminum over PVC or wood frames.The early popularity of aluminum was based on price and convenience. Aluminum was far less expensive than wood, the o...(related: Home Improvement)
Worktops And Countertops For Kitchens - Buyers Guide To Materials
Worktops and Countertops for Kitchens - Buyers Guide to MaterialsThe worktop or countertop is not only necessary for a kitchen it is also an integral part of its design. Food preparation can deliver ...(related: Home Improvement)
Swim Spas Make A Big Splash With Baby Boomers
If you are an aging baby boomer like I am, you may be looking for a fun form of water recreation where you can get some relief from aching mus...(related: Home Improvement)
How To Design A Lighting Plan
You are doing a remodel and know that you want to add some lighting to the room, but your stumped. Where do I start is the most common question I get asked. There are some basic guidelines and factors that can help you determine where to start and how t...(related: Home Improvement)
site-map - Copyright © 2007 | Contact Webmaster | All Rights Reserved | Free Articles and Information | Home Improvement